厂商 ：天津中天俊达玻纤制品有限公司
天津 天津- 主营产品：
联系电话 ：13512972377
商品详细描述
短切原丝毡或简称短切毡是将玻璃纤维原丝短切成50mm长度，均匀地降落在平面网上，用聚酯粉末（或乳液）粘结剂在一定温度下使其粘结而制成的一种玻璃纤维无纺增强材料。
Glassfiber chopped strand mat, briefly as CSM, is a non-woven reinforced material made of chopped strands of 50mm in length, uniformly distributed in plane net, with polyester powder or emulsion bonded under uniform temperature.
产品特点：Features
树脂浸透快、脱泡性好，最大限度的保证生产效率并降低成本。
Quick wetting and rapid air release, maximum molding productivity and cost-reducing.
厚薄均匀，保证用户产品各部分同质
Even thickness, same quality in different parts.
极好的干燥保留性，提高生产效率并减少在展卷、裁剪和搬动中材料的损失
Superb dry integrity, Enhance productivity and reduce materials losses during unrolling, cutting and piece handling.
卷径小，卷绕密实，货物搬运安全、高效。
Small roll diameter, tight rolls, safe and efficient material handling.
产品应用：Applications
短切毡作为一种主要的玻璃纤维无纺增强材料，是FRP手糊工艺中用量最大的增强材料，也用于一些机械成型工艺，如RTM、缠绕、模压等。典型产品有：各种板材、船艇、浴室成套设备、汽车部件和冷却塔等。
Glassfiber chopped strand mat as a main non-woven reinforced fiberglass material, is widely used in FRP handing lay-up technique, also used in mechanical molding technique, e.g. RTM, winding, mould pressing and so on. The typical products are: various board, boat and water sport, complete sets of bathroom equipment, automobiles parts, cooling tower,etc.
技术指标：Technical data
包装：Packaging
中天俊达所产短切毡，使用直径为76mm的纸管卷取，毡卷包覆聚乙烯塑料袋并装入瓦楞纸箱。如要求托盘包装时，每托盘竖放16或12箱，横放9或6箱。托盘堆高不大于2层，纸箱堆高不超过5层。
Chopped strand mat from Zhongtian Junda, is wound on cardboard tube of 76mm in diameter, then covered with a polyethylene plastic bag, and packaged in a cardboard box. If packaged with pallet, there should be 16 or 12 cartons placed vertically and 9 or 6 cartons placed horizontally on one pallet. The pallets should be stocked 2 layers high in maximum, the cartons 5 layers high in maximum when stocked .
贮存：Storage
产品应置于干燥、凉爽处，储存温度5-35°C，湿度35-65°C的环境下最佳。若不用，请勿打开包装，以免受潮，影响使用。
The product should be stored in dry and cool place where the best condition is temperature 5-35°C and the humidity 35-65°C. Unless use, the package must be kept intact in order to prevent it from the wet.
Glassfiber chopped strand mat, briefly as CSM, is a non-woven reinforced material made of chopped strands of 50mm in length, uniformly distributed in plane net, with polyester powder or emulsion bonded under uniform temperature.
产品特点：Features
树脂浸透快、脱泡性好，最大限度的保证生产效率并降低成本。
Quick wetting and rapid air release, maximum molding productivity and cost-reducing.
厚薄均匀，保证用户产品各部分同质
Even thickness, same quality in different parts.
极好的干燥保留性，提高生产效率并减少在展卷、裁剪和搬动中材料的损失
Superb dry integrity, Enhance productivity and reduce materials losses during unrolling, cutting and piece handling.
卷径小，卷绕密实，货物搬运安全、高效。
Small roll diameter, tight rolls, safe and efficient material handling.
产品应用：Applications
短切毡作为一种主要的玻璃纤维无纺增强材料，是FRP手糊工艺中用量最大的增强材料，也用于一些机械成型工艺，如RTM、缠绕、模压等。典型产品有：各种板材、船艇、浴室成套设备、汽车部件和冷却塔等。
Glassfiber chopped strand mat as a main non-woven reinforced fiberglass material, is widely used in FRP handing lay-up technique, also used in mechanical molding technique, e.g. RTM, winding, mould pressing and so on. The typical products are: various board, boat and water sport, complete sets of bathroom equipment, automobiles parts, cooling tower,etc.
技术指标：Technical data
 | 参数 Data | 玻璃类型 Glassfiber type | 幅宽 Width (mm) | 单重 Area weight (g/m2) | 卷重 Roll weight (kg) | 含潮率 Moisture content (%) | 可燃物含量 Combustible content (%) | 适用树脂 Suitable resin | 粘结剂类型 Binder type |
| 产品代号designation | |||||||||
| EMC | E glass | 200-3300 | 100-900 | 15-95 | ≤0.2 | 2.0-8.0 | UP | Powder | |
| ≤0.4 | 2.0-8.0 | UP | PVAc emulsion | ||||||
| CMC | C glass | 150-900 | 15-95 | ≤0.2 | 2.0-8.0 | UP | Powder | ||
| ≤0.4 | 2.0-8.0 | UP | PVAc emulsion | ||||||
| 注：可根据客户要求提供特殊规格产品。 Mark: Special product could be available based on customers requirements . | |||||||||
包装：Packaging
中天俊达所产短切毡，使用直径为76mm的纸管卷取，毡卷包覆聚乙烯塑料袋并装入瓦楞纸箱。如要求托盘包装时，每托盘竖放16或12箱，横放9或6箱。托盘堆高不大于2层，纸箱堆高不超过5层。
Chopped strand mat from Zhongtian Junda, is wound on cardboard tube of 76mm in diameter, then covered with a polyethylene plastic bag, and packaged in a cardboard box. If packaged with pallet, there should be 16 or 12 cartons placed vertically and 9 or 6 cartons placed horizontally on one pallet. The pallets should be stocked 2 layers high in maximum, the cartons 5 layers high in maximum when stocked .
贮存：Storage
产品应置于干燥、凉爽处，储存温度5-35°C，湿度35-65°C的环境下最佳。若不用，请勿打开包装，以免受潮，影响使用。
The product should be stored in dry and cool place where the best condition is temperature 5-35°C and the humidity 35-65°C. Unless use, the package must be kept intact in order to prevent it from the wet.
标签：
相关产品推荐
