厂商 ：天津市中天俊达玻璃纤维制造有限公司
天津 天津- 主营产品：
- 石英纤维
- 玻璃纤维维缝编毡
- 玻璃纤维短切原丝毡
产品简介：
玻璃纤维直接纱或称单股无捻粗纱是由2000孔或4000孔漏板直接拉制而成连续纤维。主要应用用于缠绕、拉挤成型工艺作，适用UP、VE、EP。典型产品为：拉挤杆、窗框、梯子、管道、通讯电缆、贮罐、织造方格布及耐化学性的格栅等。
产品特点：
张力均匀，成带性佳
树脂浸透速度快，相容性优良
毛羽少，耐磨性优
机械性能好
Introduction
Direct roving or single-end continuous roving (Pultrusion Roving, Filament Winding Roving, Weaving Roving) , made directly from a 2000 tip bushing or a 4000 tip bushing, is primarily used in filament winding and pultrusion processes in polyester ,vinylester or epoxy resin systems. Typical products are pultruded rod, window frames , ladders, pipe, telecommunication cables, tanks, woven roving and chemical resistant grating.
Features
Even Tension，excellent tapability
Fast and Complete Wet-out
No Fuzz, good abrasion resistance
参数Data
玻璃类型
Glassfiber type
公称号数
TEX
单丝直径
Filament diameter ( μm)
含水率
Moisture content (%)
可燃物含量
Combustible content (%)
强度
Filament tensile
(N/tex)
适用树脂
Suitable resin
产品代号designation
EDR
E glass
275-4800
13-24
≤0.1
0.6±0.2
≥0.3
UP、VE、EP
CDR
C glass
275-4800
13-24
≤0.2
0.6±0.2
≥0.3
UP、VE
注：1.可根据客户要求提供特殊规格产品。2.以上数据仅供参考。
Mark: 1.Special product could be available based on customers requirements .2.Reference data only, not for technical specifications.
包装：Packaging
中天俊达所产直接纱，单个纱团聚乙烯塑料袋包覆，然后放入托盘或纸箱。每个托盘可码放64或48个纱团，每个纱团重量17kg . 纸箱堆高不大于5层，托盘堆高不超过2层。
Direct roving from Zhongtian Junda , is wrapped in plastic bags , then packed in individual cardboard box or pallet . There are 64 or 48 doffs could be placed on one pallet , 17kg weight of one doff . Cardboard box can not be stacked higher than 5 layers , and pallet not higher than 2 layers .
注(Remark)：1. 托盘尺寸（长*宽*高）（cm）
Pallet dimension(length*width*height)(cm): 112*112*(94/118)
2. 纱团尺寸（长*宽*高）（cm）
Doff dimension(diameter*height)(cm):26*26
